The four tests
Size. Hold a quarter over the damage. If the chip disappears under it, it is almost certainly repairable. For a crack rather than a chip, the working limit is about six inches.
Location. Sit in the driver's seat and look straight ahead. Anything in that primary viewing area should be replaced, not repaired — a resin repair leaves a faint distortion, and a distortion in the driver's sightline is both a safety problem and a citable one. The other disqualifying location is the edge: damage touching the black frit border is always a replacement, because the edge is where the glass carries structural load.
Depth. A windshield is two layers of glass with a plastic interlayer between. If you can catch a fingernail on damage on the inside of the glass, both layers are broken and it has to be replaced.
Age. A fresh chip is a clean void that resin bonds into properly. A chip that has been open for a month is packed with road film and water, and resin will not bond into contamination. This is the test most people fail, and it is the only one that is entirely within your control.
Why the maths leans toward repair on a Q5
Here is the specific reason to care on this vehicle: a Audi Q5 windshield is an expensive part. It can carry a head-up display, which is the single largest price jump there is, a solar or infrared-reflective coating, an acoustic interlayer. A thirty-minute resin repair on a fresh chip costs a small fraction of that, and it keeps the factory seal — which is always the best seal a windshield will ever have.
There is a second reason on this car. The Audi Q5 runs VW IQ.DRIVE / Audi pre sense off a camera behind the mirror. Repair the chip and that camera never moves — no new glass, no calibration, no question about whether the aim is right. Replace the windshield and calibration becomes part of the job. Repairing early is not just cheaper, it avoids the whole conversation.
The Q5 combines almost every option that changes a windshield part number; nobody should quote one without the VIN.
Stopping it from spreading before we arrive
Put a piece of clear tape over the chip today. It will not stop the crack growing, but it keeps dirt and water out of the break, which is the single biggest factor in whether the repair later comes out clean or cloudy. Not duct tape — the adhesive bakes on.
Then stop shocking the glass with temperature. Do not aim the defroster on full heat at a cold cracked windshield, and — the Sacramento version of the same mistake — do not blast the air conditioning at a windshield that has been baking in the sun all afternoon. That sudden difference across a weakened area is exactly what turns a repairable star into a crack running the width of the glass.
Park in shade where you can, or use a sunshade. An unshaded windshield in the valley moves enormously in temperature between the afternoon and the evening.
What the repair actually is
The air is vacuumed out of the break, clear resin is injected under pressure so it reaches the tips of the cracks — which is where growth starts — then cured with UV light and polished flush. It takes about thirty minutes and you can drive immediately.
A repair restores most of the structural strength and stops the spread. It will not make the mark vanish; expect a faint blemish. Clean, recent chips come out almost invisible. Ones that sat open through a rainy week do not.
Skip the store-bought kits. They inject at low pressure and cannot evacuate the air first, so the resin never reaches the crack tips. Worse, half-cured resin from a kit often makes a proper repair impossible afterwards — a $15 kit is a reliable way to turn a repairable chip on a Audi Q5 into a full windshield replacement.
Need this done rather than explained? There is no shop to drive to. We come to wherever your car already is — your driveway, your workplace car park, an apartment lot, or the side of the road it stopped on — anywhere in greater Sacramento, with no call-out fee and no mileage charge. Give us the year, make and model and you will have a firm price before the call ends.